Research – Salmonella and Listeria monocytogenes in Ready-to-Eat Lettuce and Collard Greens – Efficacy of Sanitisers in Reducing Salmonella on Pecan Nutmeats

Ingenta Connect

This study was aimed at determining the effects of different storage scenarios on the growth potential of Salmonella strains and Listeria monocytogenes in ready-to-eat (RTE) mixes of iceberg and crisp lettuces (Lactuca sativa) and collard greens (Brassica oleracea). Vegetables were submitted to minimal processing, experimentally contaminated to achieve 10¹ and 10² CFU/g, packed under modified atmosphere and in perforated film, and submitted to the following storage scenarios: I = 100 % of the shelf life (6 days) at 7°C; II = 70 % of shelf life at 7°C and 30 % at 15°C; III = 30 % at 7°C and 70 % at 15°C; IV = 100 % at 15°C. Higher populations of Salmonella were observed in lettuce mixes than in collard greens; the opposite occurred with L. monocytogenes. Keeping the RTE vegetables at 15°C during the whole shelf life (scenario IV) or part of it (scenarios II and III) markedly influenced the growth of both pathogens in most of the scenarios studied (P < 0.05). Growth potentials of strains of Salmonella and L. monocytogenes were significantly different depending on the scenarios in samples packed with perforated film in comparison to those stored under modified atmosphere (P < 0.05). The findings indicate that even contamination as low as 10¹ CFU/g can lead to high populations if there is temperature abuse during storage (15°C). This study of the behavior of Salmonella and L. monocytogenes in RTE vegetables provides insights that may be useful in the development of strategies to control pathogen growth in these products.

Ingenta Connect

Studies were done to evaluate the efficacy of chlorine (200 to 1,000 μg/ml), lactic acid (0.5 to 2%), levulinic acid (0.5 to 2%), sodium dodecyl sulfate (SDS, 0.05%), lactic acid plus SDS, levulinic acid plus SDS, and a mixed peroxyacid sanitizer (Tsunami 200, 40 and 80 μg/ml) in killing Salmonella on or in immersion- and on surface-inoculated pecan nutmeats (U.S. Department of Agriculture medium pieces and mammoth halves). The addition of SDS to treatment solutions containing lactic acid or levulinic acid resulted in generally higher reductions of Salmonella, but differences in these reductions were not always significant. Lactic and levulinic acids (2%) containing SDS (0.05%) were equivalent in killing Salmonella on immersion-inoculated nutmeats. Tsunami 200 (40 μg/ml) was less lethal or equivalent to 1 or 2% lactic and levulinic acids, with or without 0.05% SDS. Reductions did not exceed 1.1 log CFU/g of immersion-inoculated pieces and halves, regardless of sanitizer concentration or treatment time (up to 20 min). Reductions on surface-inoculated pieces and halves were 0.7 to 2.6 log CFU/g and 1.2 to 3.0 log CFU/g, respectively. Treatment with 2% lactic acid plus SDS (0.05%) and Tsunami (80 μg/ml) was most effective in killing Salmonella on surface-inoculated pieces; treatment of halves with chlorine (1,000 μg/ml) or lactic acid (1 or 2%), with or without SDS, was most efficacious. Exposure of immersion-inoculated pecan pieces to chlorine (200 μg/ml), lactic acid (2%) and levulinic acid (2%) with or without SDS, and Tsunami (80 μg/ml) during intermittent vacuum (18 ± 2 mbar) and ambient atmospheric pressure treatments for up to 20 min reduced Salmonella by only 0.1 to 1.0 log CFU/g. These studies emphasize the importance of preventing contamination of pecan nutmeats with Salmonella. Once nuts are contaminated, the lethality of sanitizers tested in this study is minimal.